2007-2013 EZGO TXT Golf Cars Personal Vehicles Service & Repair Manual

GASOLINE POWERED GOLF CARS REVISED DATE : JANUARY 2007 TECHNICIAN’S REPAIR AND SERVICE MANUAL 605586

SAFETY (NOTES, CAUTIONS AND WARNINGS CONTINUED ON INSIDE OF BACK COVER) SAFETY For any questions on material contained in this manual, contact an authorized representative for clarification. Read and understand all labels located on the vehicle. Always replace any damaged or missing labels. On steep hills it is possible for vehicles to coast at greater than normal speeds encountered on a flat surface. To prevent loss of vehicle control and possible serious injury, speeds should be limited to no more than the maximum speed on level ground. See GENERAL SPECIFICATIONS. Limit speed by applying the service brake. Catastrophic damage to the drivetrain components due to excessive speed may result from driving the vehicle above specified speed. Damage caused by excessive speed may cause a loss of vehicle control, is costly, is considered abuse and will not be covered under warranty. For towing/transporting vehicle, refer to “TRANSPORTING VEHICLE”. Signs similar to the ones illustrated should be used to warn of situations that could result in an unsafe condition. Be sure that this manual remains as part of the permanent service record should the vehicle be sold. WASH HANDS AFTER HANDLING! Battery posts, terminals and related accessories contain lead and lead compounds, chemicals known to cause cancer and reproductive harm. BATTERY WARNING WASH HANDS AFTER HANDLING! WARNING: Battery posts, terminals and related accessories contain lead and lead compounds, chemicals known to cause cancer and reproductive harm. BATTERIES CONTAIN LEAD AND RELATED PARTS ! < 14˚ 25% DO NOT DRIVE ACROSS SLOPES IN EXCESS OF 14˚ Throughout this guide NOTE, CAUTION and WARNING will be used. A NOTE indicates a condition that should be observed. A CAUTION indicates a condition that may result in damage to the vehicle. A WARNING indicates a hazardous condition that could result in severe injury or death. Observe these NOTES, CAUTIONS and WARNINGS; be aware that servicing a vehicle requires mechanical skill and a regard for conditions that could be hazardous. Improper service or repair may damage the vehicle or render it unsafe. Engine exhaust from this product contains chemicals known, in certain quantities, to cause cancer, birth defects, or other reproductive harm. The exhaust emissions of this vehicles’ engine complies with regulations set forth by the Environmental Protection Agency (EPA) of the United States of America (USA) at time of manufacture. Significant fines could result from modifications or tampering with the engine, fuel, ignition or air intake systems. Battery posts, terminals and related accessories contain lead and lead compounds. Wash hands after handling. This spark ignition system meets all requirements of the Cana- dian Interference-Causing Equipment Regulations.

Page i Repair and Service Manual TECHNICIAN’S REPAIR AND SERVICE MANUAL GASOLINE POWERED TXT GOLF CARS & PERSONAL VEHICLES FLEET GOLF CAR (9 hp, CE, CARB) FREEDOM ™ (9 hp, CE, CARB, SE, LE, HP) SHUTTLE 2 + 2 ( 9 hp, CE, CARB) STARTING MODEL YEAR 2007 TEXTRON Golf, Turf & Specialty Products reserves the right to make design changes without obligation to make these changes on units previously sold and the information contained in this manual is subject to change without notice. TEXTRON Golf, Turf & Specialty Products is not liable for errors in this manual or for incidental or consequential damages that result from the use of the material in this manual. CUSTOMER SERVICE DEPARTMENT IN USA PHONE: 1-800-241-5855 FAX: 1-800-448-8124 OUTSIDE USA PHONE: 001-706-798-4311, FAX: 001-706-771-4609 TEXTRON GOLF, TURF & SPECIALTY PRODUCTS, P.O.BOX 388, AUGUSTA, GEORGIA USA 30906-3852

NOTES Page ii Repair and Service Manual To obtain a copy of the limited warranty applicable to the vehicle, call or write a local distributor, authorized Branch or the Warranty Department with vehicle serial number and manufacturer code. The use of non Original Equipment Manufacturer (OEM) parts may void the warranty. Tampering with or adjusting the governor to permit vehicle to operate at above factory specifications will void the vehicle warranty. When servicing engines, all adjustments and replacement components must be per original vehicle specifications in order to maintain the United States of America Federal and State emission certification applicable at the time of manufacture. BATTERY PROLONGED STORAGE All batteries will self discharge over time. The rate of self discharge varies depending on the ambient temperature and the age and condition of the batteries. A fully charged battery will not freeze in winter temperatures unless the temperature falls below -75° F (-60° C).

Page iii Repair and Service Manual TABLE OF CONTENTS TITLE PAGE Safety ........................................................................................................................... Inside Covers Notes ................................................................................................................................................. ii Safety Information ............................................................................................................................ v TITLE SECTION General Information & Routine Maintenance ................................................................................... A Safety ............................................................................................................................................... B Body ................................................................................................................................................. C Wheels and Tires ............................................................................................................................. D Front Suspension and Steering ........................................................................................................ E Speed Control .................................................................................................................................. F Engine ............................................................................................................................................. G Fuel System ..................................................................................................................................... H Continuously Variable Transmission (CVT) ..................................................................................... J Direction Selector ............................................................................................................................. K Electrical Wiring................................................................................................................................ L Brakes ............................................................................................................................................. M Rear Suspension .............................................................................................................................. N Rear Axle.......................................................................................................................................... P Weather Protection.......................................................................................................................... Q Paint ................................................................................................................................................. R Troubleshooting................................................................................................................................ S Limited Warranty .............................................................................................................................. T General Specifications ..................................................................................................................... U

Page iv Repair and Service Manual TABLE OF CONTENTS NOTES:

Repair and Service Manual Page v SAFETY INFORMATION SAFETY INFORMATION This manual has been designed to assist in maintaining the vehicle in accordance with procedures developed by the manufacturer. Adherence to these procedures and troubleshooting tips will ensure the best possible service from the product. To reduce the chance of personal injury or property damage, the following must be carefully observed: Certain replacement parts can be used independently and/or in combination with other accessories to modify an E-Z- GO-manufactured vehicle to permit the vehicle to operate at or in excess of 20mph. When an E-Z-GO-manufactured vehicle is modified an any way by the Distributor, Dealer or customer to operate at or in excess of 20mph, UNDER FERERAL LAW the modified product will be a Low Speed Vehicle (LSV) subject to the strictures and requirements of Federal Motor Vehicle Safety Standard 571.500. In these instances, pursuant to Federal law the Distributor or Dealer MUST equip the product with headlights, rear lights, turn signals, seat belts, top, horn and all other modifications for LSV’s mandated in FMVSS 571.500, and affix a Vehicle Identification Number to the product in accordance with the requirements of FMVSS 571.565. Pursuant to FMVSS 571.500, and in accordance with the State laws applicable in the places of sale and use of the product, the Distributor, Dealer or customer modifying the vehicle also will be the Final Vehicle Manufacturer for the LSV, and required to title or register the vehicle as mandated by State law. E-Z-GO will NOT approve Distributor, Dealer or customer modifications converting E-Z-GO products into LSV’s. The Company, in addition, recommends that all E-Z-GO products sold as personal transportation vehicles BE OPER- ATED ONLY BY PERSONS WITH VALID DRIVERS LICENSES, AND IN ACCORDANCE WITH APPLICABLE STATE REQUIREMENTS. This restriction is important to the SAFE USE AND OPERATION of the product. On behalf of E-Z- GO, I am directing that E-Z-GO Branch personnel, Distributors and Dealers advise all customers to adhere to this SAFETY RESTRICTION, in connection with the use of all products, new and used, the Distributor or Dealer has rea- son to believe may be operated in personal transportation applications. Information on FMVSS 571.500 can be obtained at Title 49 of the Code of Federal Regulations, section 571.500, or through the Internet at the website for the U.S. Department of Transportation - at Dockets and Regulation, then to Title 49 of the Code of Federal Regulations (Transportation). GENERAL Many vehicles are used for a variety of tasks beyond the original intended use of the vehicle; therefore, it is impossible to anticipate and warn against every possible combination of circumstances that may occur. No warnings can take the place of good common sense and prudent driving practices. Good common sense and prudent driving practices do more to prevent accidents and injury than all of the warnings and instructions combined. The manufacturer strongly suggests that all users and maintenance personnel read this entire manual paying particular attention to the CAUTIONS and WARNINGS contained therein. If you have any questions regarding this vehicle, contact your closest representative or write to the address on the back cover of this publication, Attention: Product Service Department. The manufacturer reserves the right to make design changes without obligation to make these changes on units previously sold and the information contained in this manual is subject to change without notice. The manufacturer is not liable for errors in this manual or for incidental or consequential damages that result from the use of the material in this manual.

Repair and Service Manual Page vi SAFETY INFORMATION This vehicle conforms to the current applicable standard(s) for safety and performance requirements. These vehicles are designed and manufactured for off-road use. They do not conform to Federal Motor Vehicle Safety Standards of the United States of America (USA) and are not equipped for operation on public streets. Some commu- nities may permit these vehicles to be operated on their streets on a limited basis and in accordance with local ordi- nances. Refer to GENERAL SPECIFICATIONS for vehicle seating capacity. Never modify the vehicle in any way that will alter the weight distribution of the vehicle, decrease its stability or increase the speed beyond the factory specification. Such modifications can cause serious personal injury or death. Modifications that increase the speed and/or weight of the vehicle will extend the stopping distance and may reduce the stability of the vehicle. Do not make any such modifications or changes. The manufacturer prohibits and disclaims responsibility for any such modifications or any other alteration which would adversely affect the safety of the vehicle. Vehicles that are capable of higher speeds must limit their speed to no more than the speed of other vehicles when used in a golf course environment. Additionally, speed should be further moderated by the environmental conditions, terrain and common sense. GENERAL OPERATION Always: • Use the vehicle in a responsible manner and maintain the vehicle in safe operating condition. • Read and observe all warnings and operation instruction labels affixed to the vehicle. • Follow all safety rules established in the area where the vehicle is being operated. • Reduce speed to compensate for poor terrain or conditions. • Apply service brake to control speed on steep grades. • Maintain adequate distance between vehicles. • Reduce speed in wet areas. • Use extreme caution when approaching sharp or blind turns. • Use extreme caution when driving over loose terrain. • Use extreme caution in areas where pedestrians are present. MAINTENANCE Always: • Maintain the vehicle in accordance with the manufacturer’s periodic service schedule. • Ensure that repairs are performed by those that are trained and qualified to do so. • Follow the manufacturer’s maintenance procedures for the vehicle. Be sure to disable the vehicle before performing any maintenance. Disabling includes removing the key from the key switch and removal of a battery wire.

Repair and Service Manual Page vii SAFETY INFORMATION • Insulate any tools used within the battery area in order to prevent sparks or battery explosion caused by shorting the battery terminals or associated wiring. Remove the battery or cover exposed terminals with an insulating material. • Use specified replacement parts. Never use replacement parts of lesser quality. • Use recommended tools. • Determine that tools and procedures not specifically recommended by the manufacturer will not compromise the safety of personnel nor jeopardize the safe operation of the vehicle. • Support the vehicle using wheel chocks and jack stands. Never get under a vehicle that is supported by a jack. Lift the vehicle in accordance with the manufacturer’s instructions. • Empty the fuel tank or plug fuel hoses to prevent fuel leakage. • Maintain the vehicle in an area away from exposed flame or persons who are smoking. • Be aware that a vehicle that is not performing as designed is a potential hazard and must not be operated. • Test drive the vehicle after any repairs or maintenance. All tests must be conducted in a safe area that is free of both vehicular and pedestrian traffic. • Replace damaged or missing warning, caution or information labels. • Keep complete records of the maintenance history of the vehicle. The manufacturer cannot anticipate all situations, therefore people attempting to maintain or repair the vehicle must have the skill and experience to recognize and protect themselves from potential situations that could result in severe personal injury or death and damage to the vehicle. Use extreme caution and, if unsure as to the potential for injury, refer the repair or maintenance to a qualified mechanic. VENTILATION Always store gasoline vehicles in a well ventilated area. Ventilation prevents gasoline fumes from accumulating. Never fuel a vehicle in an area that is subject to flame or spark. Pay particular attention to natural gas or propane water heaters and furnaces. Never work around or operate a vehicle in an environment that does not ventilate exhaust gases from the area. Carbon monoxide is a dangerous gas that can cause unconsciousness and is potentially lethal.

Repair and Service Manual Page viii SAFETY INFORMATION NOTES:

You're Reading a Preview

2007-2013 EZGO TXT Golf Cars Personal Vehicles Service & Repair Manual

Description

Reviews

Q&A

Recently Viewed