2009-2015 Volvo XC60 Electrical Wiring Diagrams Manual

WIRING DIAGRAM 2010 SUPPLEMENT VOLVO XC60 TP 39162202 LATE DESIGN

© Volvo Car Corporation Vehicles with SRS (Airbag)/SIPS bag/IC (Inflatable Curtain) Warning! Extra caution must be exercised when working on vehicles equipped with SRS/SIPS bag/IC in order to avoid: 1. Personal injuries when performing repair work. 2. Damage or malfunction of the SRS/SIPS bag/IC system. Work involving the SRS/SIPS bag/IC systems or other components in the vehicle that may affect the SRS/SIPS bag/IC systems must always be performed by an authorized Volvo workshop. In case of doubt, consult the SRS and SIPS bag/IC service manual. Is the vehicle equipped with SRS/SIPS bag/IC? Vehicles with SRS are most easily recognized by the letters SRS in the center of the steering wheel. If the vehicle also has a passenger side airbag, the letters SRS are stamped on the dashboard above the glove compartment. SRS vehicles from 1993 and onward also have explosive seat belt tensioners. SIPS bags are only installed on SRS vehicles from 1995 and onward. SIPS bag decals are located on the windshield and seat compartment. Vehicles with IC can be recognized by the letters IC on the C/D panel (4 door) or the B panel (5 door). General recommendations • Be especially careful when working on or around SRS, SIPS, and IC components. • Make sure that no wires are pinched, frayed, or pierced. • Never install accessories by the sensors. • Where applicable, work on the steering wheel, steering shaft, or steering gear must be done in accordance with the methods in the SRS section of VIDA. • Certain components of the aforementioned systems must be grounded while working. Read the appropriate sections in VIDA. • Install no accessories in the areas between the A and B-posts, the B and C-posts, and the C and D-posts. Test terminal Data link connector in the passenger compartment. Changes introduced up to and including June 2009 Any changes made to the vehicles after this date are not included in the manual. If necessary refer to service bulletins. Volvo models are sold in versions adapted for different markets. These adaptations depend on factors such as legal requirements, taxation, and market demands. This manual may therefore include illustrations and text that do not apply to the vehicles in your country. Ordering: Electronic Wiring Diagrams (EWDs) can be ordered from the Technical Information Shop (TIS) at www.volvocarstechinfo.ford.com/vss We reserve the right to make modifications.

TP39162202 XC60 2010 Supplement 3 Vehicles with SRS (Airbag)/SIPS bag/IC (Inflatable Curtain) ......................................................... 2 Explanations .................................................................. 6 Abbreviations ................................................................. 6 How to use the wiring diagrams 1:2............................... 7 Electrical distribution 1:3 ................................................ 9 Fuses Distribution box in engine compartment F1-F7 ............. 12 Distribution box in engine compartment F8-F23 ........... 13 Distribution box in engine compartment F27-F36 ......... 14 Distribution box in engine compartment F37-F38 ......... 15 Distribution box in engine compartment F39-F43 ......... 16 Central Electronic Module (CEM) F1 - F8..................... 17 Central Electronic Module (CEM) F9 - F19................... 18 Central Electronic Module (CEM) F20 - F24................. 19 Distribution box in passenger compartment F1 - F19... 20 Distribution box in passenger compartment F21 - F30... 21 Distribution box in cargo compartment FA1-FA11 ........ 22 Battery PF1-PF2 ........................................................... 23 Relays Relays in the engine compartment R1-R2 ................... 24 Relays in the engine compartment R8......................... 25 Relays in the engine compartment R10-R13 ............... 26 Relays in passenger compartment R1 - R4 ................. 27 Cargo compartment RA1 - RA2 ................................... 28 Ground connections Overview...................................................................... 29 31/2 - 31/XX10............................................................. 30 Control modules Central Electronic Module (CEM) 1:3 .......................... 31 Data communication high speed CAN......................... 34 Data communication intermediate speed CAN, LHD... 35 Data communication intermediate speed CAN, RHD .. 36 Data communication Local CAN.................................. 37 Data communication, LIN 1:2 ...................................... 38 Data communication MOST......................................... 40 Steering Wheel Module (SWM) ................................... 41 Group 23 Fuel system Engine management system, 4-Cyl. Turbo 1:2............ 42 Engine management system 6-Cyl. 1:2 ....................... 44 Engine management system 6-Cyl. B6324S2 1:2 ....... 46 Engine management system, 6-Cyl. Turbo 1:2............ 48 Engine management system, 5-Cyl. Diesel 1:3 ........... 50 Emission control 4-Cyl. Turbo ...................................... 53 Group 26 Cooling system Cooling fan 4-Cyl. Turbo .............................................. 54 Group 27 Engine controls Cruise control 4-Cyl. Turbo ........................................... 55 Cruise control ................................................................ 56 Group 32 Alternator and voltage regulator Power supply 4-Cyl...................................................... 57 Group 33 Starting system Starting system 4-Cyl................................................... 58 Starting system ............................................................ 59 Group 35 Lighting High and low beam ...................................................... 60 High and low beam (Dual Xenon) ................................ 61 Beam length adjustment, manual ................................ 62 Running/Parking light, Tail lights.................................. 63 Running/Parking light, Tail lights (Dual Xenon) ........... 64 Fog lights ..................................................................... 65 Brake lights .................................................................. 66 Reversing lights ........................................................... 67 Follow-me-home lighting LHD...................................... 68 Follow-me-home lighting RHD ..................................... 69 Interior lighting, LHD 1:2 .............................................. 70 Interior lighting, RHD 1:2.............................................. 72 Active headlight ........................................................... 74 Lighting in door sill trims .............................................. 75 Auxiliary lights .............................................................. 76 Table of Contents 1:3

TP39162202 XC60 2010 Supplement 4 Group 36 Additional electrical equipment Rain sensor.................................................................. 77 Direction indicator and hazard warning flashers LHD ............................................................................. 78 Direction indicator and hazard warning flashers RHD ............................................................................. 79 Wiper/Washer windshield ............................................ 80 Washer headlights ....................................................... 81 Wiper/Washer rear window.......................................... 82 Horn ........................................................................ 83 Keyless vehicle 1:2 ...................................................... 84 Anti-theft alarm ............................................................ 86 Parking assistance....................................................... 87 Collision warning with power brake booster ................ 88 Tire pressure monitoring system (TPMS) .................... 89 Alcohol lock.................................................................. 90 Group 37 Wiring and fuses Diagnostics system...................................................... 91 Outlet 12 V................................................................... 92 Cable harness towbar/tow hitch 4-pin ......................... 93 Cable harness towbar/tow hitch 7-pin.......................... 94 Cable harness towbar/tow hitch 13-pin........................ 95 USB unit (AUU)............................................................ 96 Group 38 Instruments Seat belt reminder ....................................................... 97 Driver information module............................................ 98 Group 39 Other Audio Premium 1:3 ...................................................... 99 Audio 1:2 ................................................................... 102 Cellular phone 1:2...................................................... 104 DAB Radio ................................................................. 106 Telephone system Bluetooth ..................................... 107 Bluetooth Handsfree .................................................. 108 Multimedia & Traffic information ................................ 109 Satellite radio ............................................................. 110 Parking camera.......................................................... 111 Traffic information, China........................................... 112 Traffic information, Japan .......................................... 113 Group 43 Transmission Transmission M66 ..................................................... 114 Automatic transmission TF-80SC .............................. 115 Automatic transmission MPS6 ................................... 116 Differential electronic module (DEM) ......................... 117 Group 55 Parking brake Electric parking brake ................................................ 118 Group 59 Brake system Brake control system & DSTC ................................... 119 Group 64 Steering Speed dependent power steering .............................. 120 Group 76 Shock absorbers Four-C ...................................................................... 121 Group 83 Doors and openings Central locking front doors LHD................................. 122 Central locking front doors RHD ................................ 123 Central locking rear doors .......................................... 124 Central locking tailgate............................................... 125 Central locking fuel filler flap ...................................... 126 Signal receiver central locking ................................... 127 Power windows front doors LHD................................ 128 Power windows front doors RHD ............................... 129 Power windows rear doors......................................... 130 Power sunroof ............................................................ 131 Group 84 Exterior decorative elements, etc. Power door mirrors LHD ............................................ 132 Power door mirrors RHD............................................ 133 Heated door mirrors LHD........................................... 134 Heated door mirrors RHD .......................................... 135 Blind spot information system LHD............................ 136 Blind spot information system RHD ........................... 137 Heated rear window ................................................... 138 Group 85 Interior equipment Power driver’s seat with memory function, LHD ........ 139 Power driver’s seat with memory function, RHD........ 140 Power passenger seat, LHD ...................................... 141 Power passenger seat, RHD ..................................... 142 Heated front seats ..................................................... 143 Heated rear seat ........................................................ 144 Table of Contents 2:3

TP39162202 XC60 2010 Supplement 5 Group 87 Climate control system Climate control system PTC-elements ...................... 145 Climate control system, 4-Cyl. 1:2 ............................. 146 Climate control system 5-Cyl. & 6-Cyl. 1:2 ................ 148 Parking heater, auxiliary heater ................................. 150 Parking heater, remote start ...................................... 151 Group 88 Internal equipment Rear-view mirror with automatic dimming.................. 152 Remote control opener garage door .......................... 155 Connectors .............................................. 156 Branching points ..................................... 181 Cable harness routing in vehicle Harness engine 4-Cyl. Turbo ...................................... 185 Cable harnessrouting in the car .................................. 186 Component illustrations .......................... 187 Index 1:2 .................................................... 238 List of components 1:7 ............................ 240 Table of Contents 3:3

2009-2015 Volvo XC60 Electrical Wiring Diagrams Manual

You're Reading a Preview

Recently Viewed