2007 VOLVO S80 (07-) Wiring Diagram

S80 (07-) VOLVO 2007 TP 39100202

© Volvo Car Corporation Vehicles with SRS (Airbag)/SIPS bag/ IC (Inflatable curtain) Warning! Extra caution must be exercised when working on vehicles equipped with SRS/SIPS bag/IC in order to avoid: 1. Personal injuries when performing repair work. 2. Damage or malfunction of the SRS/SIPS bag/IC system. Work involving the SRS/SIPS bag/IC systems or other components in the vehicle that may affect the SRS/SIPS bag/IC systems must always be performed by an authorized Volvo workshop. In case of doubt, consult the SRS and SIPS bag/IC service manual. Is the vehicle equipped with SRS/SIPS bag/IC? Vehicles with SRS are most easily recognized by the letters SRS in the center of the steering wheel. If the vehicle also has a passenger side airbag, the letters SRS are stamped on the dashboard above the glove compartment. SRS vehicles from 1993 and onward also have explosive seat belt tensioners. SIPS bags are only installed on SRS vehicles from 1995 and onward. SIPS bag decals are located on the windshield and seat compartment. Vehicles with IC can be recognized by the letters IC on the C/D panel (4 door) or the B panel (5 door). General recommendations • Be especially careful when working on or around SRS, SIPS, and IC components. • Make sure that no wires are pinched, frayed, or pierced. • Never fit accessories by the sensors. • Where applicable, work on the steering wheel, steering shaft, or steering gear must be done in accordance with the methods in the SRS section of VIDA. • Certain components of the aforementioned systems must be grounded while working. Read the appropriate sections in VIDA. • Do not install any accessories in the areas between the A and B-posts, the B and C-posts, and the C and D-posts. Test terminal Fuse in cargo compartment auxiliary fuse box Changes introduced up to April 2006 Any changes made to the vehicle after this date are not included in the manual. If necessary, refer to service bulletins. Volvo models are sold in versions adapted for different markets. These adaptations depend on factors such as legal requirements, taxation, and market demands. This manual may therefore include illustrations and text that do not apply to the vehicles in your country. Order number TP 39100202 Replaces previous publication 39100201 at Electronic Wiring Diagram (EWD) TP 39101001 Can also be found at Electronic Wiring Diagram (EWD) TP 39102001

TP39100202 S80(07-) 2007 3 Vehicles with SRS (Airbag)/SIPS bag/ IC (Inflatable curtain) ..................................................... 2 Explanations .................................................................. 5 Abbreviations ................................................................. 5 How to use the wiring diagrams 1:2............................... 6 Electrical distribution 1:2 ................................................ 8 Fuses Engine compartment electrical center F1-F7 ................ 10 Engine compartment electrical center F9-F21 .............. 11 Engine compartment electrical center F22-F34 ............ 12 Engine compartment electrical center F35-F38 ............ 13 Engine compartment electrical center F39-F44 ............ 14 Central Electronic Module (CEM) F1-F15..................... 15 Central Electronic Module (CEM) F17-F28................... 16 Rear electrical center FA1-FA11 .................................. 17 Rear electrical center FB1-FB7 .................................... 18 Rear electrical center FC2-FC7 .................................... 19 Rear electrical center FD1-FD7 .................................... 20 Battery PF1-PF2 ........................................................... 21 Relays Relays in the engine compartment R2......................... 22 Relays in the engine compartment R8-R9 ................... 23 Relays in the engine compartment R10-R13 ............... 24 Rear electrical center RA1-RB2................................... 25 Central Electronic Module (CEM) ................................ 26 Ground connections Overview...................................................................... 27 31/1 - 31/7 ................................................................... 28 31/10 - 31/15 ............................................................... 29 31/47 - 31/68 ............................................................... 30 31/83 - 31/89 ............................................................... 31 31/90 - 31/100 ............................................................. 32 31/XX4 - 31/AL ............................................................ 33 Control modules Overview of locations................................................... 34 Overview of designations............................................. 35 Central Electronic Module (CEM) 1:3 ........................ 36 High speed CAN data communication ....................... 39 Midspeed CAN data communication, LHD .................. 40 Midspeed CAN data communication, RHD.................. 41 LIN data communication 1:2 ...................................... 42 MOST data communication ...................................... 44 Steering Wheel Module (SWM) ................................... 45 Group 23 Fuel system Engine management system, 5 cyl. 2.5l turbo 1:2 ....... 46 Engine management system, 6 cyl. 1:2 ....................... 48 Engine management system, 8 cyl. 1:2 ....................... 50 Engine management system, 5 cyl. 2.4l diesel 1:3...... 52 Emission control, 5 cyl. 2.4l turbo ................................ 55 Emission control, 6 cyl. ................................................ 56 Emission control, 8 cyl. ................................................ 57 Group 26 Cooling system Cooling fan, 5 cyl. - 6 cyl.............................................. 58 Cooling fan, 5 cyl. 2.4l diesel ....................................... 59 Cooling fan, 8 cyl. ........................................................ 60 Group 32 Generator and voltage regulator Power supply ............................................................... 61 Group 33 Starting system Starting system ............................................................ 62 Group 35 Lighting High and low beam ...................................................... 63 High and low beam (Bi-Xenon) .................................... 64 Beam length adjustment, manual ................................ 65 Beam length adjustment, automatic (Bi-Xenon) .......... 66 Active headlights .......................................................... 67 Running/parking lights, tail lights ............................... 68 Running/parking lights, Tail lights (Bi-Xenon) ............ 69 Fog lights ..................................................................... 70 Brake lights .................................................................. 71 Reversing lights ........................................................... 72 Lighting in sill moldings ................................................ 73 Follow-me-home lighting, LHD..................................... 74 Follow-me-home lighting, RHD .................................... 75 Interior lighting, LHD 1:2 .............................................. 76 Interior lighting, RHD 1:2.............................................. 78 Auxiliary lights .............................................................. 80 Group 36 Additional electrical equipment Rain sensor .................................................................. 81 Direction indicators and hazard warning flashers, LHD ........................................................................ 82 Direction indicators and hazard warning flashers, RHD ........................................................................ 83 Windshield wiper/washer ............................................. 84 High-pressure headlight washer .................................. 85 Horn ........................................................................ 86 Anti-theft alarm ............................................................ 87 Keyless vehicle 1:2 ...................................................... 88 Parking assistance....................................................... 90 Collision warning with brake servo............................... 91 Table of Contents 1:2

TP39100202 S80(07-) 2007 4 Group 37 Wiring and fuses Diagnostics system...................................................... 92 12V outlet .................................................................... 93 Tow hitch cable harness, 4-pin .................................... 94 Tow hitch cable harness, 7-pin .................................... 95 Tow hitch cable harness, 13-pin ................................. 96 Group 38 Instruments Seat belt reminder ....................................................... 97 Driver information module............................................ 98 Group 39 Other Audio Premium 1:3 ...................................................... 99 Audio 1:2 ................................................................. 102 Cellular phone 1:2 .................................................... 104 Bluetooth phone system ............................................ 106 Multimedia & traffic information .............................. 107 Satellite radio ............................................................. 108 Group 43 Transmission M66 transmission....................................................... 109 Automatic transmission TF-80SC AWD..................... 110 Differential Electronic Module (DEM)......................... 111 Group 55 Parking brake Electronic parking brake ............................................ 112 Group 59 Brake system Brake control system & DSTC ................................... 113 Group 64 Steering Electronic power steering .......................................... 114 Group 76 Shock absorbers Four-C ...................................................................... 115 Group 83 Doors and openings Central locking, front doors, LHD............................... 116 Central locking, front doors, RHD .............................. 117 Central locking, rear doors......................................... 118 Central locking, trunk lid ............................................ 119 Central locking, fuel filler flap ..................................... 120 Signal receiver, central locking .................................. 121 Front door power windows, LHD ............................... 122 Front door power windows, RHD............................... 123 Rear door power windows ......................................... 124 Power sunroof............................................................ 125 Group 84 Exterior decorative elements etc. Power door mirrors, LHD ........................................... 126 Heated door mirrors, LHD.......................................... 127 Heated door mirrors with camera function, LHD........ 128 Power door mirrors, RHD .......................................... 129 Heated door mirrors, RHD ......................................... 130 Heated door mirrors with camera function, RHD ....... 131 Rear window defroster ............................................... 132 Group 85 Interior equipment Power driver’s seat with memory function, LHD ...... 133 Power driver’s seat with memory function, RHD ...... 134 Power passenger seat, LHD ...................................... 135 Power passenger seat, RHD ..................................... 136 Heated front seats with fans ...................................... 137 Heated front seats without fans ................................. 138 Heated rear seats ...................................................... 139 Group 87 Climate control system Climate control system, 5, 6 & 8 cyl. 1:2 .................... 140 Climate control system, 5 cyl. 2.4l diesel 1:2 ............. 142 Climate control system PTC element ....................... 144 Parking heater, auxiliary heater ................................. 145 Group 88 Internal equipment Supplemental Restraint System (SRS) 1:2 ................ 146 Electrically adjustable head restraint ......................... 148 Automatic anti-dazzle rearview mirror ...................... 149 Connectors............................................... 150 Branching points ..................................... 176 Cable harness routing in vehicle Engine harness, 5 cyl. ................................................ 191 Engine harness, 6 cyl. ................................................ 191 Engine harness, 8 cyl. ................................................ 192 Engine harness, diesel ............................................... 192 Engine compartment harness ..................................... 193 Dashboard harness, LHD ........................................... 194 Dashboard harness, RHD........................................... 195 Floor harness, LHD..................................................... 196 Floor harness, RHD .................................................... 197 Infotainment harness, LHD ......................................... 198 Infotainment harness, RHD......................................... 199 Center console harness .............................................. 200 Roof harness .............................................................. 200 Tunnel harness ........................................................... 201 Left front door harness ................................................ 202 Right front door harness ............................................. 202 Left rear door harness ................................................ 203 Right rear door harness .............................................. 203 Trunk lid harness ........................................................ 204 Rear axle harnesses ................................................... 204 Component illustrations .......................... 205 Index 1:2 .................................................... 256 List of components 1:6 ............................ 258 Table of Contents 2:2

TP39100202 S80(07-) 2007 5 Explanations Abbreviations Groups Group 23 = Fuel system Group 26 = Cooling system Group 27 = Engine controls Group 32 = Generator and voltage regulator Group 33 = Starting system Group 35 = Lighting Group 36 = Additional electrical equipment Group 37 = Wiring and fuses Group 38 = Instruments Group 39 = Other Group 43 = Transmission Group 59 = Brake system Group 64 = Steering Group 83 = Doors and openings Group 84 = Exterior decorative elements etc. Group 85 = Interior equipment Group 87 = Climate control system Group 88 = Internal equipment Ignition switch symbols X = Accessories (audio position) S = Powered upon insertion of key 15 = Contact remains connected during start 15l = Contact is broken while starting 30 = Constant power from the battery 50 = Start Countries/Markets A = Austria AUS = Australia B = Belgium CDN = Canada CH = Switzerland D = Germany DK = Denmark E = Spain EU/OS = Markets outside USA and Canada FIN = Finland GB = Great Britain ISR = Israel J = Japan KOR = Korea N = Norway NL = Netherlands S = Sweden USA = United States of America WEU = Western Europe Other AUTO = Automatic transmission CAN = CAN communication DPY = Display ECC = Electronic climate control system ETA = Electronic throttle actuator EXT. X = Extended X-feed GDL = Gas discharge lamp HISPEED = High speed data bus IR = Infrared sensor LIN = LIN communication LH = Left-hand side LHD = Left-hand drive MAN = Manual transmission MEMORY = Memory driver’s seat MIDSPEED = Midspeed data bus MMS = Mass movement sensor PETROL = Gasoline RH = Right-hand side RHD = Right-hand drive SCR = Screening SRS = Airbag T = Turbo engine W/O = Without 2WD = Two wheel drive 5CYL, I5 = 5-cylinder engine 6CYL, I6 = 6-cylinder engine 8 CYL, V8 = 8-cylinder engine Colors BK, SB = Black BN = Brown BU, BL = Blue GN = Green GY, GR = Gray LGN = Light Green NL = Natural OG, OR = Orange PK, P = Pink RD, R = Red VT, VO = Violet WH, W = White YE, Y = Yellow

You're Reading a Preview

2007 VOLVO S80 (07-) Wiring Diagram

Description

Reviews

Q&A

Recently Viewed