2010-2015 Yamaha G29 YDRA / YDRE (Gas & Electric) Golf Cart Service & Repair Manual

48 VOLT GOLF CAR YDRE LIT-19626-21-09 JW2-F8199-11

INTRODUCTION Congratulations on your purchase of a Yamaha golf car. This manual contains information you will need for proper operation, maintenance, and care of your golf car. A thorough understanding of these simple instructions will help you to obtain maximum enjoyment from your new Yamaha. If you have any questions about the operation or maintenance of your golf car, please consult a Yamaha dealer. YAMAHA GOLF-CAR COMPANY YDRE OWNER’S/OPERATOR’S MANUAL © 2009 by Yamaha Golf-Car Company 2nd Edition All rights reserved. Any reprinting or unauthorized use without the written permission of Yamaha Golf-Car Company is expressly prohibited. Printed in U.S.A. LIT-19626-21-09 i JW2

ii JW2 IMPORTANT MANUAL INFORMATION ● Yamaha continually seeks advancements in product design and quality; therefore, while this manual contains the most current product information available at the time of printing, there may be minor discrepancies between your golf car and this manual. If you have any questions concerning this manual, please consult your Yamaha dealer. ● This manual should be considered a permanent part of your golf car and should remain with the car when resold. Read and understand this manual completely before operating your golf car. Death or serious person- al injury can result from failing to comply with the warning instructions in this manual. NOTE: Particularly important information is distinguished in this manual by the following notations: The Safety Alert Symbol means ATTENTION! BE ALERT! YOUR SAFETY IS INVOLVED! Failure to follow WARNING instructions could result in severe injury or death to the golf car occupants, a bystander, or a person inspecting or repairing the golf car. This message describes special precautions that must be taken to avoid damage to the golf car. This message provides additional key information. NOTE: CAUTION !

iii JW2 1 WARRANTY CONTENTS 1 IMPORTANT LABELS 2 SAFETY CONSIDERATIONS 4 MAINTENANCE 8 STORAGE SPECIFICATIONS 9 WIRING 11 OPERATION 7 PRE-OPERATION CHECKS 6 CONTROLS 5 OPERATOR SAFETY 3 10

1 2 3 4 5 6 7 8 9 10 11 1-1 JW2 WARRANTY Yamaha Golf-Car Company hereby warrants that any new YDRA gas or YDRE electric Yamaha golf car purchased from an authorized Yamaha golf car dealer in the United States will be free from defects in material and workmanship for FOUR years from date of purchase, subject to the stated limitations. DURING THE PERIOD OF WARRANTY any authorized Yamaha golf car dealer will, free of charge, repair or replace, at Yamahaʼs option, any part adjudged defective by Yamaha due to faulty workmanship or material from the factory. Parts used in warranty repairs will be warranted for the balance of the vehicleʼs warranty period. All parts replaced under warranty become property of Yamaha Golf-Car Company. GENERAL EXCLUSIONS from this warranty shall include any failures caused by: a. Abnormal strain, neglect, or abuse, including lack of proper maintenance, and use contrary to the Ownerʼs/Operatorʼs Manual instructions. b. Accident or collision damage. c. Installation of parts or accessories that are not original equipment. d. Fading, rust, or deterioration due to exposure or ordinary wear and tear. e. Modifications or alterations that affect the carʼs condition, operation, performance, or durability, or which makes the car serve a purpose other than use as a two-person, golf course vehicle. f. Damage due to improper transportation. g. Acts of God, i.e. lightning, hail damage, flooding, fire, etc. WARRANTY COVERAGE: Year 1: The first year of warranty shall cover the entire vehicle except for the Specific Exclusions below. Year 2: The second year exclusions are the YDRA battery, body parts, seats, mats, bumper assembly, bag carrier, scorecard holder, trim, and the Specific Exclusions below. Year 3: The third year exclusions include the second year exclusions, plus the control cables and electrical system (except electronic speed controller, battery charger, and electric motor), and the Specific Exclusions below. Year 4: The fourth year of the warranty covers only the electric motor, speed controller, battery charger, and transaxle on the YDRE and the engine, clutch system (except drive belt), and transaxle on the YDRA. SPECIFIC EXCLUSIONS: Specific exclusions from this warranty shall include any parts replaced due to normal wear or routine maintenance, including oil and air filter elements, tire wear, spark plugs, starter and clutch drive belts. Any charges incurred in transporting a golf car or charger to and from an authorized Yamaha golf car dealer for service or in performing field service is also excluded from this warranty. THE CUSTOMER’S RESPONSIBILITY under this warranty shall be to: 1. Operate and maintain the golf car and charger as specified in the appropriate Ownerʼs/Operatorʼs Manual; 2. Give notice to an authorized Yamaha golf car dealer of any and all apparent defects within ten (10) days after discovery, and make the vehicle or charger available at that time for inspection and repairs by the dealerʼs authorized representative. WARRANTY TRANSFER: Any transfer of warranty must take place within the first three years of the original in-service date of the vehicle. The vehicle must be re-registered by an authorized Yamaha Golf- Car Dealer within 30 days of transfer. A fee may be charged for the transfer of the warranty. YAMAHA GOLF-CAR COMPANY MAKES NO OTHER WARRANTY OF ANY KIND, EXPRESSED OR IMPLIED. ALL IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE WHICH EXCEED THE OBLIGATIONS AND TIME LIMITS STATED IN THIS WARRANTY ARE HEREBY DISCLAIMED BY YAMAHA GOLF-CAR COMPANY AND EXCLUDED FROM THIS WARRANTY. SOME STATES DO NOT ALLOW LIMITATIONS ON HOW LONG IMPLIED WARRANTY LASTS, SO THE ABOVE LIMITATION MAY NOT APPLY TO YOU. ALSO EXCLUDED FROM THIS WARRANTY ARE ANY INCIDENTAL OR CONSEQUENTIAL DAMAGES INCLUDING LOSS OF USE. SOME STATES DO NOT ALLOW THE EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUEN- TIAL DAMAGES, SO THE ABOVE EXCLUSION MAY NOT APPLY TO YOU. THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS, AND YOU MAY ALSO HAVE OTHER RIGHTS, WHICH VARY, FROM STATE TO STATE. Yamaha Golf-Car Company, NEWNAN, GEORGIA 30265-1320 EFFECTIVE DATE: 6/1/08 LIT-13710-03-08 LIMITED 4-YEAR GOLF CAR LIMITED WARRANTY

2010-2015 Yamaha G29 YDRA / YDRE (Gas & Electric) Golf Cart Service & Repair Manual

You're Reading a Preview

Recently Viewed