2007 Volvo C30 Electrical Wiring Diagrams Manual

WIRING DIAGRAM 2007 VOLVO C30 TP 39103202

© Volvo Car Corporation Vehicles with SRS (Airbag)/SIPS bag/IC (Inflatable Curtain) Warning! Extra caution must be exercised when working on vehicles equipped with SRS/SIPS bag/IC in order to avoid: 1. Personal injuries when performing repair work. 2. Damage or malfunction of the SRS/SIPS bag/IC system. Work involving the SRS/SIPS bag/IC systems or other components in the vehicle that may affect the SRS/SIPS bag/IC systems must always be performed by an authorized Volvo workshop. In case of doubt, consult the SRS and SIPS bag/IC service manual. Is the vehicle equipped with SRS/SIPS bag/IC? Vehicles with SRS are most easily recognized by the letters SRS in the center of the steering wheel. If the vehicle also has a passenger side airbag, the letters SRS are stamped on the dashboard above the glove compartment. SRS vehicles from 1993 and onward also have explosive seat belt tensioners. SIPS bags are only installed on SRS vehicles from 1995 and onward. SIPS bag decals are located on the windshield and seat compartment. Vehicles with IC can be recognized by the letters IC on the C/D panel (4 door) or the B panel (5 door). General recommendations • Be especially careful when working on or around SRS, SIPS, and IC components. • Make sure that no wires are pinched, frayed, or pierced. • Never install accessories by the sensors. • Where applicable, work on the steering wheel, steering shaft, or steering gear must be done in accordance with the methods in the SRS section of VIDA. • Certain components of the aforementioned systems must be grounded while working. Read the appropriate sections in VIDA. • Install no accessories in the areas between the A and B posts, the B and C posts, and the C and D posts. Test terminal Data link connector in the passenger compartment. Changes introduced up to September 2006 Any changes made to the vehicles after this date are not included in the manual. If necessary refer to service bulletins. Volvo models are sold in versions adapted for different markets. These adaptations depend on factors such as legal requirements, taxation, and market demands. This manual may therefore include illustrations and text that do not apply to the vehicles in your country. Order number TP 39103202 Replaces previous publication 39103201 concerning Electronic Wiring Diagram (EWD) TP 39107201 Can also be found on Electronic Wiring Diagram (EWD) TP 39110201

TP 39103202 C30 2007 3 Vehicles with SRS (Airbag)/SIPS bag/IC (Inflatable Curtain) ......................................................... 2 Abbreviations ................................................................. 7 How to use the wiring diagrams 1:2............................... 8 Electrical distribution 1:2 .............................................. 10 Fuses Engine compartment distribution box F1-F10 ............... 12 Engine compartment distribution box F11-F18 ............. 13 Engine compartment distribution box F20-F31 ............. 14 Engine compartment distribution box F32-F34 ............. 15 Engine compartment distribution box F35-F36 ............. 16 Distribution box in engine compartment FH1................ 17 Central Electronic Module (CEM) F43-F49................... 18 Central Electronic Module (CEM) F51-F63................... 19 Central Electronic Module (CEM) F64-F74................... 20 Central Electronic Module (CEM) F79-F86................... 21 Battery PF1-PF2 ........................................................... 22 Fuses in holder ............................................................. 23 Relays Ignition switch and relays............................................. 24 Distribution box in engine compartment R2-R14 ......... 25 Central Electronic Module (CEM) R15-R18 ................. 26 Central Electronic Module (CEM) R1 - R11B .............. 27 Relays - accessories.................................................... 28 Ground connections Overview...................................................................... 29 31/3 - 31/10 ................................................................. 30 31/11 - 31/52 ............................................................... 31 31/66 - 31/67 ............................................................... 32 31/80 - 31/89 ............................................................... 33 31/110 - 31/119 ........................................................... 34 Ground connections in chassis .................................... 35 Control modules Overview of locations................................................... 36 Overview of designations............................................. 37 Central Electronic Module (CEM)1:2 ......................... 38 Data communication, Low speed CAN 1:2 ................ 40 Data communication, High speed CAN ..................... 42 Data communication MOST ...................................... 43 Data communication LIN 1:2 ..................................... 44 Start Control Module (SCU) ....................................... 46 Group 23 Fuel system Engine management system Diesel, 5-cyl. 2.4l 1:3 ..... 47 Engine management system, 4-cyl. 1.6l 1:2 ................ 50 Engine management system, 4-cyl. 1.8l & 2.0l 1:2...... 52 Engine management system, 5-cyl. 1:2....................... 54 Engine management system, 5-cyl. Turbo 1:2 ............ 56 Engine management system Diesel, 4-cyl. 1.6l 1:2 ..... 58 Engine management system Diesel, 4-cyl. 2.0l 1:2 ..... 60 Emission control, 4-cyl. 1.6l ......................................... 62 Emission control 4-cyl. 1.8l & 2.0l ................................ 63 Emission control, 5-cyl................................................. 64 Emission control, 5-cyl. Turbo...................................... 65 Group 26 Cooling system Cooling fan................................................................... 66 Cooling fan, Diesel ....................................................... 67 Group 27 Engine control Cruise control, 4-cyl. ..................................................... 68 Cruise control, 5-cyl. ..................................................... 69 Group 32 Alternator and voltage regulator Power supply, 4-cyl...................................................... 70 Power supply, 5-cyl...................................................... 71 Group 33 Starting system Starting system, 4-cyl................................................... 72 Starting system, 5-cyl................................................... 73 Starting system, 5-cyl. Diesel....................................... 74 Group 35 Lighting High and low beam ...................................................... 75 High and low beam (Bi-Xenon) .................................... 76 Manual beam length adjustment .................................. 77 Automatic beam length adjustment (Bi-Xenon) ........... 78 Position/Parking lights, Tail lights ............................... 79 Position/Parking lights, Tail lights (Bi-Xenon) ............. 80 Fog lights ..................................................................... 81 Fog lights LHD Japan .................................................. 82 Brake light .................................................................... 83 Reversing light ............................................................. 84 Follow-me-home lighting .............................................. 85 Interior lighting 1:2 ....................................................... 86 Instrument and control illumination .............................. 88 Auxiliary lights .............................................................. 89 Table of Contents 1:3

TP 39103202 C30 2007 4 Group 36 Additional electrical equipment Direction indicator and hazard warning flashers ......... 90 Direction indicator and hazard warning flashers (Bi-Xenon).................................................................... 91 Wiper/washer ............................................................... 92 Headlight washer ......................................................... 93 Rear window wiper/washer .......................................... 94 Rain sensor.................................................................. 95 Horn ........................................................................ 96 Immobilizer/Steering column lock module (SCL) ........ 97 Keyless vehicle 1:2 ...................................................... 98 Rear parking assistance ............................................ 100 Front parking assistance............................................ 101 Anti-theft alarm .......................................................... 102 Alcolock ..................................................................... 103 Group 37 Wiring and fuses 12V outlet ................................................................. 104 Diagnostics system.................................................... 105 Tow hitch cable harness, 4-pin .................................. 106 Tow hitch cable harness, 7-pin .................................. 107 Tow hitch cable harness, 13-pin ................................ 108 Group 38 Instruments Driver information module.......................................... 109 Seat belt reminder ..................................................... 110 Group 39 Other Multimedia & Traffic information ................................ 111 Audio 1:2 ................................................................... 112 Audio High Performance/Premium Sound 1:2 ........... 114 Cellular phone 1:2...................................................... 116 Satellite radio ............................................................. 118 Group 43 Transmission Automatic transmission AW55-51.............................. 119 Transmission M66 ..................................................... 120 Group 59 Brake system Brake control system & DSTC ................................... 121 Group 64 Steering Electronic power steering........................................... 122 Group 83 Doors and openings Central locking ........................................................... 123 Central locking, trunk lid/tailgate ................................ 124 Central locking, fuel filler flap ..................................... 125 Signal receiver, remote-control, central locking ......... 126 Power windows .......................................................... 127 Power sunroof ............................................................ 128 Group 84 Exterior decorative elements, etc. Power rear view mirrors ............................................. 129 Heated door mirrors ................................................... 130 Heated rear window ................................................... 131 Blind Spot Information System................................... 132 Group 85 Interior equipment Power driver’s seat with memory function, LHD ....... 133 Power driver’s seat with memory function, RHD........ 134 Power passenger seat with memory function, LHD ............................................................ 135 Power passenger seat with memory function, RHD ............................................................ 136 Heated seats.............................................................. 137 Group 87 Climate control system Climate control system, 4-cyl. Gasoline 1:2 ............... 138 Climate control system, 5-cyl.1:2 ............................... 140 Climate control system, Diesel 1.6l & 2.0l 1:2............ 142 Climate control system PTC element ....................... 144 Parking heater, auxiliary heater ................................. 145 Electric engine heater Flexifuel .................................. 146 Group 88 Internal equipment Auto-dimming rearview mirror .................................... 147 Supplemental Restraint System (SRS) 1:2 ................ 148 Connectors............................................... 150 Branching points ..................................... 175 Table of Contents 2:3

TP 39103202 C30 2007 5 Routing of the cable harnesses in the vehicle Engine harness, Gasoline 4-Cyl 1.6 ......................... 184 Engine harness, Gasoline 4-Cyl 1.8 ......................... 184 Engine harness, Gasoline 5-Cyl ................................. 185 Engine harness, Gasoline 5-Cyl Turbo ....................... 185 Engine harness, Diesel 1.6l ........................................ 186 Engine harness, Diesel 2.0l ........................................ 186 Engine harness, Diesel 2.4l ........................................ 187 Engine compartment harness, 4-Cyl. ......................... 188 Engine compartment harness, 5-Cyl. ........................ 188 Dashboard harness, LHD ........................................... 189 Dashboard harness, RHD........................................... 189 Floor harness, LHD..................................................... 190 Floor harness, RHD .................................................... 191 Roof harness .............................................................. 192 Tunnel harness ........................................................... 192 Driver’s door harness.................................................. 193 Passenger door harness............................................. 193 Trunk lid harness ........................................................ 194 Component images .................................. 195 Index 1:2 .................................................... 239 List of components 1:5 ............................ 241 Table of Contents 3:3

TP 39103202 C30 2007 6

TP 39103202 C30 2007 7 Groups Group 23 = Fuel system Group 26 = Cooling system Group 27 = Engine controls Group 32 = Alternator and voltage regulator Group 33 = Starting system Group 35 = Lighting Group 36 = Additional electrical equipment Group 37 = Wiring and fuses Group 38 = Instruments Group 39 = Other Group 43 = Transmission Group 59 = Brake system Group 64 = Steering Group 83 = Doors and openings Group 84 = Exterior decorative elements, etc. Group 85 = Interior equipment Group 87 = Climate control system Group 88 = Internal equipment Ignition switch symbols X = Accessories (audio position) S = Powered upon insertion of key 15 = Contact remains connected during start 15l = Contact is broken while starting 30 = Constant power from the battery 50 = Start Countries/Markets A = Austria AUS = Australia B = Belgium CDN = Canada CH = Switzerland D = Germany DK = Denmark E = Spain EU/OS = Markets outside USA and Canada FIN = Finland GB = Great Britain ISR = Israel J = Japan KOR = Korea N = Norway NL = Netherlands S = Sweden USA = United States of America WEU = Western Europe Other AUTO = Automatic transmission CAN = CAN communication D = Diesel DPY = Display ECC = Electronic climate control system ETA = Engine throttle body EXT. X = Extended X-feed GDL = Gas discharge lamp HISPEED = High speed data bus IR = Infrared sensor LIN = LIN communication LHD = Left-hand drive LOSPEED = Low speed data bus MAN = Manual transmission MEMORY = Memory driver’s seat MMS = Mass Movement Sensor GASOLINE = Gasoline RHD = Right-hand drive SCR = Screened SRS = Airbag T = Turbocharged engine W/O = Without 2WD = Two-wheel drive 4CYL, I4 = 4-cylinder engine 5CYL, I5 = 5-cylinder engine Colors BK, SB = Black BN = Brown BU, BL = Blue GN = Green GY, GR = Gray LGN = Light Green OG, OR = Orange PK, P = Pink RD, R = Red VT, VO = Violet WH, W = White YE, Y = Yellow Explanations Abbreviations

TP 39103202 C30 2007 8 The descriptions below apply in general to all wiring diagram manuals, although not all sections are necessarily con- tained in this manual. How to use the wiring diagrams 1:2 A. Component designation Every component has a component designation that consists of two parts. The first part is a type number that describes the type of component in question, for example 3/xx. The second part of the designation is a serial number, e.g. x/2. Together, this constitutes a component designation, e.g. 3/2. At the end of the manual is a list of components, where, with the help of the component designation, you can read off the name of the component, for example, 3/2 = light switch. List of type numbers The list shows which type of component that respective type numbers refer to, for example, 3/x = switch, 6/x = electric motor, etc. 1 Battery 2 Relay 3 Switch 4 Control module 5 Driver information module 6 Electric motor 7 Sensor 8 Actuator 9 Heating element 10 Light 11 Fuse 15 Electrical distribution rail/box 16 Audio 17 Service/diagnostics 18 Contact reel 19 Meter 20 Ignition component/shunt 27 Optics 31 Ground connection 63 Branching point 64 Connector B. Branching points The wiring diagrams contain numbered junction points, e.g. 63/352. This manual contains a section with a list of branching points. This list shows all the components that are connected to each branching point. The location of the branching points is shown in the "Cable harness routing in vehicle" section. C. Connectors Connectors provide a bridge between two cable harnesses and are described in the "Connectors" section. D. Electrical distribution Operation of the fuses and relays is shown in the "Electrical distribution" section. E. Data communication Today’s cars contain CAN and MOST networks that transfer information. Connections to these networks are not shown in their entirety in the respective wiring diagram. Complete information on CAN and MOST communication is found in the section "Con- trol modules". F. Abbreviations A number of different abbreviations are used in the manual. These are explained in the section "Abbre- viations". G. Component location There is a section at the end of the manual in which the appearance and location of components is described in numerical order.

TP 39103202 C30 2007 9 How to use the wiring diagrams 2:2 Explanation of symbols = System voltage = Ground connection via wiring = Ground connection in component/chassis = Screened wire = Junction point = Twisted cable = Electrical connection = Variant = CAN communication = CAN high data signal (CAN H) = CAN low data signal (CAN L) = LIN communication = LIN communication = DIN cable, coaxial cable, etc. = Data communication = CAN communication = MOST communication = MOST communication = Connection with distribution box = Further connection to... = Connector between cable harnesses = Connector connected in component LIN CAN 1 1 G E A C F B D DIM 9 10 5/1 30+ 1 2 F3 SWM 3/254 C:9 C:8 CAN CAN 15/31 2 F26 1 30 15 50 X S 5 B:3 B:7 RD 5 RD 3/1 64/111 1 2 F69 2/193 1 2 5 4 7/149 WH-GN OG-BK 2 3 1 CEM 31/84 CAN BK BK 3 LHD 31/110 RSM LIN 63/12 2 RHD 1 LHD 4 RHD G:3 A:14 BK 63/214 BK H:7 H:23 D:10 R18 4/56 E:20 GN-HW RD-OG WH-GN A:17 LIN 6/1 WMM LIN 63/108 BK BK 3 W/O KVM BK 31/10 BK 63/25 A:28 BK M 7_209

TP 39103202 C30 2007 10 Electrical distribution 1:2 Overview F E C 1 F36 F34 F35 F33 F32 3 2 5 5 3 1 2 3 5 1 2 F10 F17 F14 BK-WH GN-BU 2/32 R14 R13 2/35 R10 2/82 F12 F13 F9 RD-OG RD-OG RD-GN RD-OG RD-OG A 15/31 6/25 50 31 M ACM 30 B:1 6/26 B+ 31 G B:1 A:1 RD RD 12V BK 31/3 1/1 BK 31/4 PF2 PF1 RD RD-OG 40 14 39 64/90=15/31A 8/84:1 7/51:6 64/90=15/31A 11 4 BK-RD GY 64/90=15/31A 41 12 21 BK-BU GN-BU GN-BU GN-YE GN-YE GN-BU GN-YE B I4 I5 Diesel Diesel BK-RD GN-BU 2 1 1 2 35 63/13 GN-YE GN-YE GN-YE 5 cyl I4 Diesel D 64/90= 15/31A 31 64/90 9 GN-BU GN-BU GN-BU GN-BU GN-BU 64/113 6 GN-BU 6 B:11 B:29 B:17 B:33 ECM 4/46.1-3 CAN LIN 5 CYL 4/31 6/1 4/110

2007 Volvo C30 Electrical Wiring Diagrams Manual

You're Reading a Preview

Recently Viewed