2008-2009 Dodge Caravan Service & Repair Manual
What's Included?
Lifetime Access
Fast Download Speeds
Offline Viewing
Access Contents & Bookmarks
Full Search Facility
Print one or all pages of your manual
2009 GENERAL INFORMATION
Mopar Accessories - Grand Caravan, Town & Country
AUDIO AND ELECTRONICS
INSTRUCTION SHEET
WI-FI ROUTER
MINIVAN
PROCEDURE STEPS:
Fig. 1: Fasteners
Courtesy of CHRYSLER LLC
1. Move the passenger seat to the full rearward position.
2. Disconnect the negative battery cable.
3. Remove the six fasteners (2) on both sides of the storage bin.
4. Carefully disengage the two spring clips from the top center of the bin and pull the storage bin towards
the rear of the vehicle.
NOTE: Using a test light, verify the cigarette lighter outlet being used is ignition
switched. Power must not be present with the ignition in the OFF position.
2009 Dodge Grand Caravan SE
2009 GENERAL INFORMATION Mopar Accessories - Grand Caravan, Town & Country
2009 Dodge Grand Caravan SE
2009 GENERAL INFORMATION Mopar Accessories - Grand Caravan, Town & Country
Fig. 2: Wi - Fi Power Harness
Courtesy of CHRYSLER LLC
5. Route the Wi-Fi power harness (1) under the carpet from the passenger seat to the instrument panel
storage bin (2).
Fig. 3: Power Harness Connector
Courtesy of CHRYSLER LLC
6. Secure the Wi-Fi Router under the passenger seat (1) with the supplied tie straps and Velcro® tape (3).
7. Connect the power harness connector (2) to the Wi-Fi router.
NOTE: Do not use the power outlet for the power supply to the Wi-Fi router.
2009 Dodge Grand Caravan SE
2009 GENERAL INFORMATION Mopar Accessories - Grand Caravan, Town & Country
Fig. 4: Adhesive Lined Heat Shrink Tubing
Courtesy of CHRYSLER LLC
8. Locate the cigarette lighter outlet wiring harness.
9. Cut each wire and remove 13 mm (0.5 in.) of insulation from each wire that needs to be soldered/spliced.
10. Place a piece of supplied adhesive lined heat shrink tubing on one side of each cut wire. Insure the tubing
will be long enough to cover and seal the entire soldered area.
11. Solder the supplied fused pigtail to Wi-Fi power harness power wire.
Fig. 5: Splice Clip
Courtesy of CHRYSLER LLC
CAUTION: Do not use acid core solder.
2009 Dodge Grand Caravan SE
2009 GENERAL INFORMATION Mopar Accessories - Grand Caravan, Town & Country
12. Place the strands of the power side wires overlapping each other inside of the splice clip (1).
Fig. 6: Crimping Splice Clip & Wires Together
Courtesy of CHRYSLER LLC
13. Using crimping tool (1), Mopar® p/n 05019912AA or equivalent, crimp the splice clip and wires
together.
14. Repeat the previous two steps for the ground side wires.
Fig. 7: Soldering Connection
Courtesy of CHRYSLER LLC
15. Solder (3) the connection (2) together using rosin core solder (1).
2009 Dodge Grand Caravan SE
2009 GENERAL INFORMATION Mopar Accessories - Grand Caravan, Town & Country
Fig. 8: Heat Shrink Tubing
Courtesy of CHRYSLER LLC
16. Center the heat shrink tubing (2) over the solder joint and heat using a heat gun. Heat the joint until the
tubing is tightly sealed and sealant (1) comes out of both ends of the tubing.
Fig. 9: Fasteners
Courtesy of CHRYSLER LLC
17. Position storage bin into place and connect the electrical connectors
18. Seat the storage bin and engage the spring clip retainers.
19. Install the six fasteners (2) on both sides of the storage bin.
20. Connect the negative battery cable.
21. Verify system operation.
2009 Dodge Grand Caravan SE
2009 GENERAL INFORMATION Mopar Accessories - Grand Caravan, Town & Country
You're Reading a Preview
What's Included?
Lifetime Access
Fast Download Speeds
Offline Viewing
Access Contents & Bookmarks
Full Search Facility
Print one or all pages of your manual
$31.99
Viewed 21 Times Today
Secure transaction
What's Included?
Lifetime Access
Fast Download Speeds
Offline Viewing
Access Contents & Bookmarks
Full Search Facility
Print one or all pages of your manual
$31.99
The 2008-2009 Dodge Caravan Service & Repair Manual is a comprehensive guide to diagnosing, repairing, and maintaining your vehicle. It provides detailed procedures and step-by-step instructions, making it an essential resource for both professional technicians and DIY enthusiasts.
This manual features:
- Detailed sub-steps for repair procedures with clear, numbered instructions
- Important notes, cautions, and warnings to highlight critical information
- Bold figure numbers and detailed illustrations, drawings, and photos to guide you
The manual covers a wide range of topics including:
- General information and specifications
- Engine removal, wiring diagrams, and lubrication points
- Periodic maintenance and engine servicing
- Disassembly and reassembly procedures
- Fuel and lubrication systems, electrical system, and ignition
- Chassis, steering, suspension, gearbox, and exhaust system
Available in .PDF format, this manual is compatible with all versions of Windows and Mac. It is fully printable and can be saved directly to your hard drive for instant access without additional shipping costs or waiting times.
Whether you are a professional mechanic or a DIY enthusiast, the 2008-2009 Dodge Caravan Service & Repair Manual delivers all the critical information needed to effectively diagnose and repair both electrical and mechanical systems.
